BUSCADOR RECOLECTA

The temperature dependence of the constrained amorphous interphase or rigid amorphous fraction (RAF) in bio-based semi-crystalline poly(ethylene 2,5-furandicarboxylate) (PEF) was assessed. RAF, which is located in proximity of the basal crystal planes, was found to develop in parallel with the crystal phase during crystallization at the lowest investigated Tcs, i.e. 130 and 140 °C, at which the less stable α′-crystal phase grows. At higher Tcs, RAF does not vitrify during crystallization, but only upon the subsequent cooling down to Tg. The rigid amorphous fraction at Tg increases by decreasing the crystallization temperature, ranging approximately from 15 to 25%. This information is useful for the development of PEF products, since many RAF physical properties, for example mechanical and barrier properties, are different from those of the amorphous fraction far from the crystals. RAF decreases with increasing temperature, and becomes zero around 150 °C. The same temperature limit of 150 °C was found to influence the reversing crystallization/melting process at the lateral crystal surfaces, as well as the crystallization rate, which reaches its maximum at temperatures above 150 °C. In addition, singularly, the more ordered crystalline α-form was found to grow only at temperatures higher than 150 °C. The total absence of constraints on the amorphous segments mobility, identified at temperatures higher than 150 °C, also favors additional crystallization upon heating in the PEF samples crystallized at low Tcs, with also α-crystals development. The densities of the RAF connected to α′- and α-crystals were estimated at room temperature., This article is based upon work from COST Action FUR4Sustain, CA18220, supported by COST (European Cooperation in Science and Technology). XRD measurements were performed with a Bruker AXS D8 ADVANCE Plus diffractometer at the PanLab department facility, founded by the MIUR-“Dipartimenti di Eccellenza” grantNExuS. D.C. acknowledges financial support from the project PGC2018-094548-B-I00 (MICINN-Spain and FEDER-UE) and the project IT-1175-19 (Basque Government)., Peer reviewed